• some Dash Lights only go on at Night, can't be seen in the day time.

    From micky@21:1/5 to All on Wed May 12 14:34:14 2021
    XPost: alt.home.repair, sci.electronics.repair

    I renamed the thread and moved it from its original location to the
    bottom of the list so I wouldn't have to hunt for it so much.


    On Tue, 11 May 2021 22:35:56 -0400, Clare Snyder <clare@snyder.on.ca>
    wrote:

    On Tue, 11 May 2021 16:42:39 -0400, micky <NONONOmisc07@fmguy.com>
    wrote:

    In alt.home.repair, on Sun, 09 May 2021 00:32:57 -0400, Clare Snyder >>><clare@snyder.on.ca> wrote:
    .....
    No they didn't. They had full 24 volt systems including the >>>>alternator on all diesel Cruisers. At least all the ones sold in
    Canada before 2000. To operate 12 volt accessories required a buck >>>>converter. I used to produce and provide a system to adapt them to tow >>>>12 volt trailers. I was also a Toyota service manager back then.
    .

    Maybe you can help me then. I have a 2005 Toyota Solara and it has 3 >>>"meters" above the radio that, unless sunlight is shining right on them >>>through the back window, I can't read in the daytime.

    After dark, a backlight goes on for them and they're easy to read.

    These are the clock, the trip info gizmo (MPG, DTE, MPH, and ET), and
    the outside temperature.

    Is is this the way it was designed, or is something broken?


    I've been trying to rewire things so the lights are on all the time >>>whenever the car is running.


    I know this is a 2005 car and the only date you mention is 2000, but
    does any of this ring a bell?


    I have the factory wiring manual for 2005 Solaras (plus the online >>>version for 2006). It seems to refer to all three meters as the Clock

    It uses a photocell on the dashboard to turn the speedo cluster and
    other lights (glovebox; radio, AC, and seat heater buttons, shift >>>indicator) on when it gets dark, from the Taillight relay through the >>>Panel fuse (which is separate from the Taillight fuse). The wiring >>>diagram seemed to confirm that the car was designed this way, because it >>>shows a lightbulb labeled Clock in the saem circuit in parallel with

    So I found 12v that were on whenever the engine was running, at the Seat >>>Heater switch, and removed the Panel fuse and shorted the 12volts at the >>>switch to the Panel light wire at that switch. And now all the lights
    go on all the time, EXCEPT the three I care about.

    When this didn't work, I used a heavy dark rag to cover the photocell
    and I can trick the headlights into going on during the day, but >>>amazingly the Clock light isn't tricked.



    Any ideas what I should do next?


    Posted and mailed
    I was out of the dealership by then, but a simple piece of duct tape
    over the sensor will turn the head lights on constantly when the
    engine is running. That SHOULD turn on the instrument lights.

    Okay, I tried that and it did turn on the headlights and taillights.
    BUT the ones in question** didn't go on.

    Yet up until the last time I drove in the dark, two nights ago, they do
    go on at night. I will try tonight and see if they still go on at
    night, but how that could be different from covering the photocell I
    don't know.


    FWIW there are actually two photocells but I covered both of them. When
    I first got the car I asked on ToyotaNation or the other one what the
    second one was for, and if I got an answer, I forget what it was. Each
    as a domed plastic cover but one is 1/4" high or more and the other much shorter. I wonder why.


    **(Most of the other lights are too dim to see during the daytime, but
    they work fine already.)

    e-mail me the schematic / wiring diagram and I'll look at it

    It will take a bit of time to extract the relevant pages from my 390
    page wiring diagram. I'll work on it.

    Does it get dimmer when the headlights are on? It should.

    One thing only does dim and that's the little dot/light on the dash that
    shows what gear I'm in, and I think that's fair because the other lights
    are powered directly from 12v. I haven't tested when the headlights go
    on, but instead, I removed the Panel fuse and ran a jumper from the 12v-when-engine-on to one of the locations the Panel fuse powers**, and
    when I touch the jumper to that, the dot on the dash goes dimmer and
    when I remove it it goes back to full daytime brightness. That is
    reliable.

    Sometimes!!! when I do touch the jumper that way, the "clock" lights go
    on, but unreliably and rarely. It will work, then 3 minutes later, it doesn't. And this testing was done at night (they weren't on to begin
    with I used to think because the panel fuse was out, but later I think
    they went on without the panel fuse or the hot-wire. I have to do more
    testing tonight. Prior testing was very confusing, so I hoped you'd
    just know the answer already, although I suppose it's very unlikely
    people would complain about something like this and that your service department would try to rewire a car that was working according to the
    Toyota spec.

    In the daytime I've never gotten them to go on.

    Do you think there's any chance, once I have the current operation
    totally clear and written down, if I wrote to Toyota, they'd tell me why
    it works that way, or even how to change it? I figure they'd ignore me
    or tell me to go to a dealer.

    Most of the lights*** are powered directly from the battery when the
    Taillight relay is closed, via the Panel fuse, and they don't dim, but
    normally they only go on at night. I guess going on is the opposite of dimming.

    **From the 12v that powers the seat heater switch to the light for the
    seat heater switch, so the wires are only a half inch away from each
    other. I thought it would be such an elegant fix, except it doens't
    work for the "clock" lights. It does light up all the other lights
    below***.

    ***The speedo cluster, glovebox, the buttons for the radio, heater/ac,
    seat heater switches, and the gearshift indicator on the center console.

    And there is a light in the speedometer needle that changes in some way.
    I think it lights up at night. It's really all very nice except for my
    one complaint. I would have thought lots of people would complain and
    by 2006 they would have changed it. I have the digital version of 2006.
    It's harder to read than on paper, but I checked to the extent I could
    and haven't found any differences related to this. Maybe that they
    didn't change it would mean mine is broken, not misdesigned. But I
    still should be able to fix it.

    I'll do more testing when it gets dark, which seems to be different from
    having the photocells covered.

    It should
    DIM when the headlights are on and be brigher during the day I think.

    Yes, those gear indicator dots works that way.

    Is this an orange/red light? or green?

    In the speedo cluster, there's a little light for each gear. Park is
    green. I think the others are different.


    2005 Toyota Solara (similar to a Camry)

    --- SoupGate-Win32 v1.05
    * Origin: fsxNet Usenet Gateway (21:1/5)